您現在的位置：丝瓜视频下载App → 新聞資訊 → 超聲資訊

使用超聲波清洗機，這些注意事項要牢記！

日期： 2021-05-16

瀏覽次數: 78

來源：

作者：固特超聲-李淑雅

發布日期： 2021-05-16

瀏覽次數： 78

1.注意謹慎使用清洗液

在使用超聲波清洗機的時候，必須要按照規范要求的順序進行操作，特別是不可以先開機然后再把清洗液倒進去，這屬于違規操作會引發嚴重的后果甚至會損壞機器，因此一定要先把液體放進去然后再打開開關。同時還應該要顧及到清洗液的成分，如果它含有易燃性質的液體那么一定要在短時間內完成操作，并且全程都要有人監督，不可以離開現場。

2.注意使用腐蝕或揮發性清洗液要做特殊處理

通常情況下是不提倡使用危險性清洗液的，但如果情況比較特殊，強調超聲波清洗機廠家必須要使用含有腐蝕性或揮發性的液體，那么應該要采取間接的方式來進行妥善的處理。具體的操作方法是在清洗槽里面先加水，然后再另外用一個容器裝清洗液并放入需要清洗的物品，然后在它們浸入清洗槽的水里面，用這種方式來進行清洗該也會在同樣的效果，又可以保證安全的問題。

3.超聲波清洗機電源及電熱器電源必須有良好接地裝置。

4.超聲波清洗機嚴禁在槽中沒有水或溶劑時，千萬不要啟動，造成空振，造成振動頭報廢或損壞。

5.有加熱系統的清洗設備嚴禁無液時打開加熱開關。

6.禁止用重物（鐵件）撞擊清洗缸缸底，以免能量轉換器晶片受損。

7.超聲波發生器電源應單獨使用一路220V/50Hz電源并配裝2000W以上穩壓器。

8.清洗缸缸底要定期沖洗，不得有過多的雜物或污垢。

9.清洗機操作過程中請勿將手指放入清洗槽中，否則會感到刺痛或者不適。

10.每次換新液時，待超聲波起動后，方可洗件。

11.采用清水或水溶液作為清洗劑，絕對禁止使用酒精，汽油或任何可燃氣體作為清洗劑加入清洗機中。

12.當直接使用易燃液體清洗時，要盡量在短時間內完成清洗工作，并要求操作者不要離開現場。

13.當需要用腐蝕性或揮發性強的清洗液時，可采用間接清洗的方法。即：首先在清洗槽內加水，再將所需清洗液倒入適宜的容器內并放入被清洗物，然后將裝有清洗液和清洗物的容器浸入清洗槽中，即可開始清洗工作，其效果與直接清洗相同。

14.使超聲波清洗效果最佳的方式，超聲波清洗槽的溫度最好為30~50℃，根據不同的清洗對象正確選擇清洗劑。清洗劑一般分為水基（堿性）清洗劑、有機溶劑清洗劑和化學反應清洗劑。通常使用最多的為水基清洗劑，根據被清洗物的污染程度和污垢性質，選用不同的清洗時間。

15.在使用時禁止先開機后倒入清洗液，這樣會使機器損壞。

16.清洗物品不要直接放在清洗槽底部，應用專用清洗支架清洗筐，這樣有利于提高清洗效果。

17.盡量避免長時間連續工作，一般不超過30分鐘為宜。

18.在使用時槽內清洗或脫氣的溶液不要放入過少，一般在槽內2/3處最佳。

19.注意控制好清洗的相關因素

固特超聲建議大家不要把需要清洗的東西放在最底端，應該要用專門清洗的支架進行架空放在中間的位置，這樣一來在進食的時候就可以均勻的受力獲得好的清洗效果。同時固特作為超聲波清洗專家，還要提醒大家注意所放入的清洗液能量。

上一篇：如何正確使用超聲波清洗器？下一篇：超聲波焊接機的組成及采購注意事項

相關新聞 / News More
超聲波清洗機安全操作規程

點擊次數: 39

2021 - 06 - 21

超聲波清洗機安全操作規程有哪些？下面，我們廣東固特超聲波清洗機公司小編來為您介紹：一、清洗范圍1.本機為專人專管設備，其他人不得擅自操作。2.超聲波清洗機用于零部件的二次清洗，未經清洗過的零部件不得放入本機清洗。3.本機清洗范圍：發動機缸體、缸蓋、曲軸、凸輪軸、連桿活塞、空壓機等發動機零部件，軸承、方向機、變速器的軸及齒輪、減速器齒輪等。二、操作方法1.清洗池內加入適量清水，液面高度以浸沒側振盒為準。2.合上控制柜后面板上的電源開關，啟動電控加熱開關，將水溫調節旋鈕上的白色刻度線指向適當的溫度，一般夏天為50℃—55℃冬季為60℃－65℃。在使用過程中，清洗液的溫度不得超過70℃。3.先用水桶將清洗劑用溫水沖開攪勻，使其充分溶解，待清洗槽水溫升至40℃左右時加入水槽中。清洗劑按1～2%兌水稀釋（清洗劑約5～9公斤）。4.將零部件置于網筐中輕輕放入清洗池內，分布均勻。清洗零件應達清洗槽內60％以上再開機，以免嘯叫，損壞電源。5.水溫達到預定值后開機清洗，將超聲波底部與側部功率旋鈕順時針旋至較大，按下超聲波啟動按鈕，清洗開始。若要停止清洗，直接按超聲波停止按鈕。6.定時清洗：先設定清洗時間，將定時開關置開位，再順時針將兩功率旋鈕旋至較大，按下超聲波啟動按鈕清洗開始，達到定時時間后，超聲波電源將自動關閉.7.清洗完畢后要關閉超聲波電源，再取出清洗好的零部件，用壓縮空氣將各孔道中的殘留清洗液徹底吹盡，并將表面吹干。8.若清洗池液面上存有過多油污，應打開溢流裝置將其排除，以防被清洗工件的二次污染。以上是廣東固特超聲股份有限公司小編為大家作解答的幾點。超聲波清洗機、小型超聲波清洗機、全自動超聲波、醫用超聲波清洗劑、超聲波清洗設備、就找廣東固特超聲公司，我們在四川、梅州以及深圳地區都有公司哦(e)O(∩_∩)O~恭候~
超聲波清洗機值得買嗎？

點擊次數: 48

2021 - 06 - 21

超聲波清洗機值得買嗎(ma)？下面，我們廣東固特超聲波清洗機公司小編來為您介紹：相信眼鏡黨們都深有體會，眼鏡戴久了，真的是會臟到模糊，還有我們看不到的各種污漬、細菌……不過現在再也不用擔心了，這樣一個小小的超聲波清洗機就能輕松搞定，不但是眼鏡，男朋友的剃須刀、女朋友的首飾、化妝刷或者是小寶寶的奶嘴小口哨都能清洗哦！相信很多人都不了解超聲波清洗，這是廣泛應用在機械行業、醫療行業的一種清洗技術，只需要加入清水，它就能利用超聲波技術產生“空化作用”，迅速清除物品表面的污漬、細菌、灰塵……可以說是360°無死角，而且還不用擔心會損傷物品。會選擇大宇的這款清洗機，主要還是因為它的顏值，無論放在家里的哪個角落，都是一件養眼的裝飾品。清洗機里面還配了一個洗首飾的網狀盒子，這樣可以避免把首飾弄壞，個人覺得這點還蠻貼心的！
超聲清洗設備的重要性

點擊次數: 62

2021 - 06 - 21

超聲波清洗設備有什么重要性，下面，我們廣東固特超聲波清洗機公司小編來為您介紹：超聲清洗技術的機理研究及設備開發與超聲清洗工藝研究及應用在我國已有近50年的歷史,幾乎與國外同步進行的。80年代前我國超聲清洗研制單位無論從研制隊伍和生產有一定規模的單位為數不多,80年代后特別90年代開始隨著改革開放的深入和國民經濟的飛速發展以及科技的不斷進步，尤其先進制造技術的需求，超聲清洗技術的研究與超聲清洗設備的研制得到了迅速發展，研制隊伍不斷壯大，研制單位不斷增多。超聲清洗是屬于物理力清洗，其本身為綠色清洗，若在清洗液中添加適宜的清洗劑則屬組合清洗，更具明顯的清洗效果。超聲清洗是目前功率超聲中應用最為廣泛的一種，超聲清洗與現代科技發展及先進制造工藝密切相關。超聲清洗在各種化學、物理以及機械的清洗中是較為有效的一種，它被廣泛應用于機械、光學、電子、輕工、紡織、化工、航空航天、船舶、原子能以及醫療醫藥等工業部門。超聲波清洗器的原理是由超聲波發生器所發出的高頻振蕩訊號，通過換能器轉換成高頻機械振蕩而傳播到介質－－清洗液中，超聲波在清洗液中疏密相間地向彰輻射，使液體流動而產生數以萬計的微小氣泡，這些氣泡在超聲波縱向傳播的負壓區形成、生長，而在正壓區迅速閉合，在這種被稱之為“空化”效應的過程中氣泡閉合可能成超過去1000個氣壓的瞬間高壓，連續不斷產生的高壓就象一連串小“爆炸”不斷的沖擊物件表面，使物件表面及縫隙中的污垢迅速剝落。所以達到物件全面潔凈的清洗效果。超聲波清洗對任何物件的材質及精度不受影響。超聲波清洗與其它清洗相比具有洗凈率高、殘留物少,清洗時間短,清洗效果好，凡是能被液體浸到的被清洗件，超聲對它都有清洗作用。不受清洗件表面形狀限止，例深孔、狹縫、凹槽。都能得到清洗。由于超聲波發生器采用D類工作放大,換能器的電聲效率高，因此超聲清洗具有高效節能。它是一種真正高速、高質量、能易實現自動化的...
超聲波清洗機散熱解決的辦法

點擊次數: 56

2021 - 06 - 18

超聲波清洗機散熱該怎么解決？下面，小編為大家講解：超聲波在液體中傳播，使液體與清洗槽在超聲波頻率下一起振動，液體與清洗槽振動時有自己固有頻率，這種振動頻率是聲波頻率，所以人們就聽到嗡嗡聲。隨著清洗行業的不斷發展，越來越多的行業和企業都運用到了超聲波清洗機。超聲波清洗機的優點是：超聲波清洗效果好，操作簡單。超聲波清洗機廣泛應用于表面噴涂處理行業、機械行業、電子行業、醫療行業、半導體行業、鐘表首飾行業、光學行業、紡織印染行業。超聲波電機彈性振動體的振動速度和依靠摩擦傳遞能量的方式決定了它是一種低速電機，同時其能量密度是電磁電機的5到10倍左右，使得它不需要減速機構就能低速時獲得大轉矩，可直接帶動執行機構，能量密度大也導致了在散熱不佳的情況下，超聲波內部過熱，直接影響性能的穩定。由于超聲波清洗機需要用的環境比較多，有時對于噪音的處理上需要很謹慎。這就要求，散熱方面的噪音不能過高。而我們也都知道，用風冷散熱時，風扇會隨著熱量的提升而加快轉速，從而使得噪音很大。另外，風扇散熱還會容易堆積灰塵，對于內部環境和零部件有不利的影響。那么有沒有更好的散熱方式呢？答案是水冷散熱。在眾多的散熱方式中，水冷散熱已經開始嶄露頭角。優秀的散熱效果，靜音模式，綠色安全穩定都極大改變了以往的散熱方式。在眾多領域已經開始使用水冷散熱，如新能源、LED、激光等，加快了水冷散熱的發展。超聲波清洗機也不例外，已經有不少企業開始采用這種散熱方式。在將來會有更多設備引進水冷散熱。超聲波清洗機有了水冷散熱的幫助，就能發揮更大的價值。水冷散熱也能保證清洗機的效率和壽命，一舉兩得。
超聲波清洗機的原理及優勢

點擊次數: 25

2021 - 06 - 18

超聲波清洗機有哪些原理跟優勢呢？下面，固特小編為大家介紹：眾所周知，在點膠過程生中，需要對所用到的各種點膠閥、膠杯、針筒、膠盤等多種點膠配件進行清洗。而傳統的清洗方式清洗不夠徹底又會污染環境。所以超聲波清洗技術受到行業的青睞。超聲波清洗機經過翻轉注水、超聲清洗、內外沖洗、空氣吹干、翻轉等流程而實現的。超聲波清洗機原理主要是通過換能器，將功率超聲頻源的聲能轉換成機械振動，通過清洗槽壁將超聲波輻射到槽子中的清洗液。由于受到超聲波的輻射，使槽內液體中的微氣泡能夠在聲波的作用下從而保持振動。液體在高頻交替變化作用下形成無數空化泡（“空化效應”）,并在內部發生快速爆裂，在聲波對空化泡保持振動，能有效高頻率撞擊污物表層，污物被層層破壞和剝離，從而達到清洗效果。在LED封裝過程中常見點膠閥，螺桿閥體上沾滿環氧膠水，需要人工用清洗劑進行清洗，在清洗過程中，生產人員每天重復呼吸著揮發的清洗劑氣味，久而久之，給人體健康帶來了很大的隱患。雖然有戴口罩，但其實形同虛設沒有多大作用。而超聲波清洗機適用丙酮、LED專業清洗劑等化學用品，對人體無傷害。而且操作簡單，采用PLC控制系統全自動上下料，一人就可以操作。超聲波清洗機選用全自動上下治具夾具清洗，每次可安放四個治具套籃，治具在清洗劑超聲波清洗時自動蓋板蓋住清洗劑槽體，防止清洗劑的揮發性和減少清洗劑氣味的散發對人體傷害。超聲波清洗機采用雙清洗槽功能性強。可單獨控制二次清洗，保障最佳清洗效果還能節約成本。
多槽式超聲波清洗機的使用注意事項？

點擊次數: 16

2021 - 06 - 04

超聲波清洗機對于如今的清洗行業來說，是不可缺少的產品。它的出現解決了清洗難題，提高了清洗行業的清洗工作效率，同時解決人工清洗費時費力的問題。在很多領域都可以使用多槽式超聲波清洗機來進行物品的清洗，因為這樣清洗出來的物品比手工清洗的潔凈程度更高，但是要想獲得更好的清洗質量，大家除了要按照要求來進行操作各項程序之外，還需要了解多槽式超聲波清洗機的使用注意事項。現在，我們廣東固特超聲波清洗機公司小編為您介紹：1.清洗籃在使用多槽式超聲波清洗機清洗一些較小的零件物品時經常需要使用清洗筐，但是清洗筐上的網眼會引起超聲衰減，所以要特別引起注意，注意選擇網眼大小合適的清洗籃，此外建議選用不銹鋼材質的清洗籃，盡量不要使用塑膠框，這樣能夠防止靜電的產生。2.清洗時間通常在清洗時每道工序的時間定為三至五分鐘，如果被清洗物品的表面積比較大，或者工件的結構較為復雜時，要注意根據實際情況酌情調整多槽式超聲波清洗機的清洗時間。若被清洗物容易出現重疊以及粘附的現象，那么在將被清洗物放入及取出槽液的時候可以抖動一下工件，讓清洗劑充分與工件接觸以提高清洗效果。3.加液和串槽用多槽式超聲波清洗機清洗工件要注意槽液不能加得太滿，以免發生兩槽超聲波清洗劑之間相互混合以及瀝干時清洗筐底部黏液的現象。此外，多槽式超聲波清洗機的每個槽應為獨立的操作工序，注意不要將兩槽清洗劑相互串用或人為減少操作工序以及清洗的操作時間。以上是固特小編為大家介紹使用多槽式超聲波清洗機清洗工件時需要大家多注意的幾點。多槽式超聲波清洗機盡管擁有非常高的清潔性能，但那是在按照及規定和要求進行操作的情況下，只有在使用超聲波清洗機清洗工件時按程序執行才會得到最好的清洗效果。
購買超聲波的技巧

點擊次數: 8

2021 - 06 - 04

相信不少人對超聲波清洗機有所了解了，但是想購買超聲波清洗機的時候卻發現種類實在太多，不知道購買哪一種的比較好。下面就教大家三個技巧，挑選優質的超聲波清洗機。下面，我們廣東固特超聲波清洗機公司小編來為您介紹：看超聲頻率市面上的超聲波清洗機，大多數頻率在40~50kHz左右，這個頻率階段是最中庸的頻段，符合絕大多數場景的使用。但是正式因為這個頻段使用最多，導致振子（即換能器）的質量不一。而擁有高頻（100kHz左右）或者低頻（25kHz）頻段的超聲波清洗機，其振子質量相對較好，尤其某些雙頻的機器，其振子一定優于單頻的機器。所以在選購時，條件允許的話，可以優先選擇雙頻的機器，然后根據被清洗物選擇高頻還是低頻。看功率功率越高，清洗效果越好，這是毋庸置疑的。但是過高的功率會對被清洗物有所腐蝕，所以功率太大了也不好。那么應該怎么選擇呢？其實部分廠家也考慮到了這一點，所有，有的清洗機設備是可以自行調整超聲功率的，1%~99%可調。帶有功率可調功能的設備，條件允許的話盡量往大功率的買。聽聲音聽聲音，是指設備工作時的聲音。理論上來說，超聲波是人耳聽不到的聲音，但是在實際中，超聲波清洗機是會發出一定的噪音的，這是由于各種原因造成的。當兩款設備，材質基本相同，功率和頻率也相同時，哪一個的噪音小，說明質量比較好。原因是：振子工作時不是100%處于超聲頻段的，好的振子處在超聲頻段的時間較多，噪音就小。噪音小，說明材料之間的密封性好，也就是制造工藝要求比較高，這樣的設備更加耐用。說明廠家是真實的為客戶著想，這樣的廠家在產品和服務上會更好。以上是廣東固特超聲股份有限公司小編為大家作解答的幾點。超聲波清洗機、小型超聲波清洗機、全自動超聲波、醫用超聲波清洗劑、超聲波清洗設備、就找廣東固特超聲公司，我們在四川、梅州以及深圳地區都有公司哦(e)O(∩_∩)O~恭候~
超聲波清洗機的頻率應如何科學選擇？

點擊次數: 55

2021 - 05 - 25

大家在選購超聲波清洗機的時候都會注意到一個參數，那就是頻率。超聲波清洗機的頻率種類很多，比如25kHz、30kHz、50kHz等。那么在選擇的時候選擇哪一頻率的更好呢？不同頻率有什么區別？關于超聲波清洗機的頻率應如何科學選擇？下面，我們廣東固特超聲波清洗機公司小編來為您介紹：為了方便解讀，本文中將頻率較高的超聲波稱為高頻超聲波，同理，頻率較低的超聲波稱為低頻超聲波。當我們看到25000Hz、30000Hz、50000Hz這些參數的時候，大概率會先入為主的認為頻率越高也就也好。事實上就清洗效果而言，高頻的反而沒有低頻的清洗效果好。當然，我說的是相對而言，并不是說高頻超聲波的清洗效果就不好。一款家用的超聲波清洗機，它的頻率是45kHz，而它的應用范圍主要是清洗眼鏡、表帶、首飾等物件，適合精密清洗。而低頻的超聲波則適合大一點的、材質比較粗糙不怕損傷的物件，比如工業中的一些金屬工件等。低頻超聲波的空化效應更強，能量更大，清洗效果更好，但是對被清洗物的傷害也更大；高頻超聲波的空化效應較弱，清洗效果相對較弱，但是對物件傷害較小，適合精密的物品清洗。所以在選擇超聲波清洗機的時候，應該根據被清洗物來選擇。很多單頻的超聲波清洗機的頻率都是在40kHz左右，因為這是一個很適中的頻段，適合生產生活中的大多數情形使用。以上是廣東固特超聲股份有限公司小編為大家作解答的幾點。超聲波清洗機、小型超聲波清洗機、全自動超聲波、醫用超聲波清洗劑、超聲波清洗設備、就找廣東固特超聲公司，我們在四川、梅州以及深圳地區都有公司哦(e)O(∩_∩)O~恭候~
超聲波清洗機能夠洗哪些東西？

點擊次數: 39

2021 - 05 - 25

想了解超聲波清洗機的人，經常會問的問題是：超聲波清洗機能夠洗哪些東西？下面，我們廣東固特超聲波清洗機公司小編來為您介紹：超聲波清洗機應用非常廣泛，可以用來清洗的東西如下：電子/電氣工業行業：半導體元件（如硅片、集成電路）、各類高低壓電器（如繼電器、開關、電路板、電位計等）、各類電機、壓縮機、各類電氣元件、真空器件等。光學、光電、光伏行業：光學玻璃及組件、光電玻璃及組件、光伏玻璃及組件等。雖然有的會例舉具體的行業，但是看完之后依舊迷茫，可能是那些例舉的行業中沒有你所在的行業，也可能是看完過后反而有點不相信了。下面，我們將以一個外行人的視角，來判斷超聲波清洗是否適合自己所在的行業。首先，超聲清洗需要將被清洗物浸沒到液體中，所以要確保的是，被清洗物是可以允許浸沒清洗的。所以，一些電子設備就不太適合（雖然現在手機都可以防水了，但不建議嘗試）。其次，超聲清洗更適用于材質較硬的物質，比如金屬、陶瓷等。材質越軟，超聲清洗的效果也就越差。所以，超聲清洗并不適用于洗衣物等。原因很簡單，材質較硬的物質吸音效果弱，不會降低超聲波在液體中的各種效應；而材質較軟的物質吸音效果比較強，會降低超聲波在液體中的各種效應，從而降低清洗效果。最后，超聲波清洗機雖然不貴，但還是有一定的成本，如果有成本更低的清洗方式也就沒必要換成超聲清洗了。超聲清洗的清洗效果好，清洗成本低，如果您所在的行業可以使用超聲清洗的方式，不妨嘗試一下，會有不錯的效果。以上是廣東固特超聲股份有限公司小編為大家作解答的幾點。超聲波清洗機、小型超聲波清洗機、全自動超聲波、醫用超聲波清洗劑、超聲波清洗設備、就找廣東固特超聲公司，我們在四川、梅州以及深圳地區都有公司哦O(∩_∩)O~恭候~
實驗室超聲波清洗機頻率越高越好嗎？

點擊次數: 73

2021 - 05 - 20

實驗室超聲波清洗機是一種針對實驗室高潔凈度需求而研發的一種新型清洗設備。其可以實現自動化清洗各種實驗玻璃器皿、精密器械，解決傳統人工清洗費時費力、效果難以把控的弊端，還能避免研究人員暴露在有害的清洗試劑中，起到改善實驗室清洗環境的作用。眾所周知，超聲波清洗是基于空化效應，其是決定超聲波清洗效果的重要因素，而超聲波頻率則會直接影響到空化效應，所以很多人在采購實驗室超聲波清洗機的時候會著重關注頻率這一參數。大家都知道頻率是物質在1s內完成周期性變化的次數，那什么是超聲波頻率呢？顧名思義，是指聲波在每秒鐘內完成周期性變化的次數，例如20KHz，即聲波在每秒產生20000次的振動。由于各行業所需要清洗的工件及污垢的不同，使用的超聲波清洗頻率也有所不同。超聲波應用于清洗領域的頻率大致可分為低頻、中頻、高頻、兆頻幾個等級。一般清洗常用到的頻率有28KHz、40KHz、68Khz、80KHz、120KHz等，其中40KHz是各行業中使用最為廣泛的一種頻率。面對如此多少頻率選擇，在實驗室使用的超聲波清洗機哪種頻率比較合適呢？實驗室超聲波清洗機頻率越高越好嗎？空化效應是隨著頻率的升高而降低的，頻率低，空化容易產生，清洗液體受到的壓縮和稀疏作用有更長的時間間隔，使得空化氣泡在爆破前能生長到較大的尺寸，增高空化強度，一般適用于清洗污垢和工件表面結合度高的領域；高頻超聲波，則反之。由此可知，中低頻通常用來清洗大顆粒污垢，中高頻用來清洗微米級的污垢，兆頻則可以用來清洗微米、亞微米級的污垢。實驗過后的器皿、器械通常有不同大小的污物顆粒附著在表面上，因此在實驗室領域可根據清洗需求選擇不同超聲波頻率組合，以便于達到最佳的清洗效果。

丝瓜视频下载App

使用超聲波清洗機，這些注意事項要牢記！

QQ設置

SKYPE 設置

阿里旺旺設置

服務熱線

二維碼管理